480 1.7i, ,, ,1721 cc ,1986-88 ,Engine Code B18E

Ignition data

480 1.7i,
Ignition system type: El-ecu
Ignition coil make/type: Fen/S100620
Supply voltage: n / a
Primary resistance: 0.4-0.8 Ohms
Secondary resistance: 2500-5500 Ohms
Distributor make/type: n / a
Contact breaker gap/air: n / a mm
Dwell angle: n / a Deg
Ignition Timing - unleaded: n / a Deg eng/rpm (without vacuum)
Ignition Timing - leaded: n / a Deg eng/rpm (without vacuum)
Timing mark location: Flywheel
No 1 plug location: N/S/F
Firing Order: 1-3-4-2
Spark plug make: AC Delco
Spark plug type: CR41CXLS
Electrode gap: 0.7 mm

Fuel System

480 1.7i,
Fuel type: L/U
Fuel pump type/pressure: Mech/3.5 bar
Engine idle speed: 800
50 rpm
Fast idle speed: n / a rpm
CO level at idle speed: 0.5-2.0 Vol %

Engine Data

480 1.7i,
Valve clearance - inlet: 0.20 c mm (cold)
Valve clearance - exhaust: 0.40 c mm (cold)
Compression pressure: 11-13 bar
Oil pressure: 3.5/3000 bar/eng/rpm
Radiator pressure cap: 1.5 bar/type
Drive belt 1 - size: PV/KKB113 mm/type
Drive belt 2 - size: n / a mm/type

Electrical System

480 1.7i,
Alternator output: 54/3000 Amps/eng/rpm
Regulated output: 13.5-15.0 Volts
Battery: 12/55 V/Ah
Starter motor make/type: P.R/D9E771

Other data

480 1.7i,
Clutch operation type: Cable
Clutch adjustment: 35-40 Above B.Ped. mm
Cambelt failure: Damage
Cambelt Part Number: 3343720-3
Tyre pressures: 2.1(30)f 1.9(28)r bar (psi)

Component Locations
Fuel Filter: 10
Fuel Pump: 16
ECU-Fuel: 11
ECU-Ignition: 1
Fuel Pump Relay: 12
Fuel Injection Relay: 12
Ignition Power Relay: 12

Check location diagram