Home › General › SPECIFICATIONS › HYBRID / BATTERY CONTROL

HYBRID / BATTERY CONTROL > SERVICE DATA



Reserve Tank Cap (for Inverter) 
Item
Specified Condition
Standard value (for brand-new cap)
94 to 122 kPa (1.0 to 1.2 kgf/cm2, 13.6 to 18 psi)
Minimum standard value (for used cap)
94 kPa (1.0 kgf/cm2, 13.6 psi)

Relay 
Item
Tester Connection
Specified Condition
IGCT relay
Resistance
3 - 5
10 kΩ or higher
(No auxiliary battery voltage is applied across terminals 1 and 2)
3 - 5
Below 1 Ω
(Auxiliary battery voltage is applied across terminals 1 and 2)

Hybrid Battery Junction Block Assembly 
SMRB
Resistance
4 (SMRB) - 2 (GND)
19.0 to 35.5 Ω (at -40°C (-40°F) to 80°C (176°F))
SMRG
Resistance
1 (SMRG) - 2 (GND)
19.0 to 35.5 Ω (at -40°C (-40°F) to 80°C (176°F))
SMRP
Resistance
3 (SMRP) - 2 (GND)
112 to 274 Ω (at -40°C (-40°F) to 80°C (176°F))
Precharge
resistor
-
28.5 to 31.5 Ω
Electric vehicle fuse
-
Below 1 Ω

Service plug grip 
Service plug grip
Always
Below 1 Ω

Combination Switch Assembly 
EV switch
H72-3 (S) - H72-14 (E)
Below 1 Ω
(EV switch being pushed and held)
10 kΩ or higher
(EV switch not operated)
SPORT mode switch
H72-6 (PWR) - H72-14 (E)
Below 1 Ω
(Mode switch being turned and held at SPORT position)
10 kΩ or higher
(Mode switch not turned)
ECO mode switch
H72-5 (ECO) - H72-13 (E)
Below 1 Ω
(Mode switch being turned and held at ECO position)
10 kΩ or higher
(Mode switch not turned)
NORMAL mode switch
H72-4 (NORM) - H72-14 (E)
Below 1 Ω
Mode switch being pushed and held at NORMAL position
10 kΩ or higher
Mode switch not pushed
seat heater switch
3 (RV) - 4 (SW)
LH Side
0.28 to 0.42 kΩ
(Off)
0.28 to 0.42 kΩ
(On (Min.))
2.72 to 4.08 kΩ
(On (Max.))
1 (REL1) - 6 (SW)
0.28 to 0.42 kΩ
(Off)
0.28 to 0.42 kΩ
(On (Min.))
2.72 to 4.08 kΩ
(On (Max.))