ENGINE ASSEMBLY > REMOVAL


  1. DISCHARGE FUEL SYSTEM PRESSURE

  2. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL

  3. REMOVE FRONT WHEEL

  4. DRAIN ENGINE OIL

  5. DRAIN ENGINE COOLANT

  6. DRAIN AUTOMATIC TRANSMISSION FLUID

  7. REMOVE COOL AIR INTAKE DUCT SEAL

  8. REMOVE ENGINE ROOM COVER SIDE RH

  9. REMOVE ENGINE ROOM SIDE COVER LH

  10. REMOVE V-BANK COVER SUB-ASSEMBLY

  11. REMOVE ENGINE UNDER COVER

  12. REMOVE NO. 2 ENGINE UNDER COVER

  13. REMOVE FRONT EXHAUST PIPE ASSEMBLY

  14. REMOVE PROPELLER WITH CENTER BEARING SHAFT ASSEMBLY

  15. REMOVE NO. 1 AIR CLEANER INLET

  16. REMOVE AIR CLEANER ASSEMBLY WITH HOSE

  17. DISCONNECT RADIATOR HOSE INLET

  18. DISCONNECT RADIATOR HOSE OUTLET

  19. DISCONNECT RADIATOR RESERVE TANK HOSE

  20. DISCONNECT UNION TO CHECK VALVE HOSE

  21. DISCONNECT HEATER WATER INLET HOSE A

  22. DISCONNECT HEATER WATER OUTLET HOSE A

  23. DISCONNECT FUEL MAIN TUBE

  24. REMOVE ENGINE ECM COVER

  25. DISCONNECT ENGINE WIRE

  26. REMOVE FAN AND GENERATOR V BELT

  27. REMOVE COMPRESSOR WITH PULLEY ASSEMBLY

  28. DISCONNECT HEIGHT CONTROL SENSOR LINK

  29. REMOVE FRONT SUSPENSION MEMBER PROTECTOR LOWER

  30. REMOVE TIE ROD ASSEMBLY RH

  31. REMOVE TIE ROD ASSEMBLY LH

  32. REMOVE FRONT SHOCK ABSORBER ASSEMBLY RH

  33. REMOVE FRONT SHOCK ABSORBER ASSEMBLY LH

  34. REMOVE NO. 2 STEERING INTERMEDIATE SHAFT ASSEMBLY

  35. REMOVE FRONT LOWER BALL JOINT RH

  36. REMOVE FRONT LOWER BALL JOINT LH

  37. DISCONNECT POWER STEERING LINK WIRE HARNESS

  38. DISCONNECT FLOOR SHIFT GEAR SHIFTING ROD SUB-ASSEMBLY

  39. REMOVE ENGINE AND TRANSMISSION ASSEMBLY

  40. REMOVE AUTOMATIC TRANSMISSION ASSEMBLY

  41. REMOVE DRIVE PLATE AND RING GEAR SUB-ASSEMBLY

  42. REMOVE FRONT ENGINE MOUNTING INSULATOR

  43. FIX ENGINE ON ENGINE STAND

  44. REMOVE ENGINE WIRE

  45. REMOVE OIL DIPSTICK SUB-ASSEMBLY

  46. REMOVE EXHAUST MANIFOLD SUB-ASSEMBLY RH

  47. INSPECT EXHAUST MANIFOLD SUB-ASSEMBLY RH

  48. REMOVE EXHAUST MANIFOLD SUB-ASSEMBLY LH

  49. INSPECT EXHAUST MANIFOLD SUB-ASSEMBLY LH

  50. REMOVE GENERATOR ASSEMBLY

  51. REMOVE NO. 2 IDLER PULLEY SUB-ASSEMBLY

  52. REMOVE V-RIBBED BELT TENSIONER ASSEMBLY

  53. REMOVE WATER PUMP PULLEY

  54. DISCONNECT NO. 1 WATER BY-PASS HOSE

  55. DISCONNECT NO. 2 WATER BY-PASS HOSE

  56. REMOVE REAR ENGINE COVER SUB-ASSEMBLY

  57. REMOVE NO. 3 WATER BY-PASS PIPE

  58. REMOVE NO. 4 WATER BY-PASS PIPE

  59. REMOVE INTAKE AIR SURGE TANK SUB-ASSEMBLY

  60. INSPECT INTAKE AIR SURGE TANK SUB-ASSEMBLY

  61. REMOVE FUEL PRESSURE PULSATION DAMPER ASSEMBLY

  62. REMOVE FUEL DELIVERY PIPE SUB-ASSEMBLY

  63. REMOVE FUEL INJECTOR ASSEMBLY

  64. REMOVE INTAKE MANIFOLD

  65. INSPECT INTAKE MANIFOLD

  66. REMOVE KNOCK SENSOR

  67. REMOVE ENGINE MOUNTING BRACKET RH

  68. REMOVE ENGINE MOUNTING BRACKET LH

  69. REMOVE OIL FILLER CAP SUB-ASSEMBLY

  70. REMOVE IGNITION COIL ASSEMBLY

  71. REMOVE ENGINE OIL LEVEL SENSOR

  72. REMOVE OIL PRESSURE SWITCH ASSEMBLY

  73. REMOVE ENGINE COOLANT TEMPERATURE SENSOR