BRAKE PEDAL > INSTALLATION

1. INSTALL BRAKE PEDAL SUPPORT ASSEMBLY (w/ VSC)

2. INSTALL BRAKE PEDAL SUPPORT ASSEMBLY (w/ ECB)

3. INSTALL BRAKE BOOSTER GASKET (w/ VSC)

4. INSTALL BRAKE BOOSTER ASSEMBLY (w/ VSC)

5. INSTALL BRAKE MASTER CYLINDER PUSH ROD CLEVIS (w/ VSC)

6. INSTALL BRAKE PEDAL RETURN SPRING (w/ VSC)

7. INSTALL ABS AND TRACTION ACTUATOR ASSEMBLY WITH BRACKET (w/ VSC)

8. INSTALL BRAKE MASTER CYLINDER WITH PLATE CYLINDER SUB-ASSEMBLY (w/ VSC)

9. INSTALL ENGINE ROOM RELAY NO.3 BLOCK (w/ VSC)

10. INSTALL BRAKE BOOSTER GASKET (w/ ECB)

11. INSTALL BRAKE MASTER CYLINDER ASSEMBLY WITH STROKE SIMULATOR (w/ ECB)

12. INSTALL BRAKE MASTER CYLINDER PUSH ROD CLEVIS (w/ ECB)

13. INSTALL BRAKE PEDAL RETURN SPRING (w/ ECB)

14. INSTALL BRAKE ACTUATOR ASSEMBLY WITH ACTUATOR BRACKET (w/ ECB)

15. INSTALL RESERVOIR TUBE NO.1 HOSE (w/ ECB)

16. INSTALL SKID CONTROL ECU ASSEMBLY (w/ ECB)

17. INSTALL ENGINE ROOM RELAY NO.3 BLOCK (w/ ECB)

18. CONNECT CABLE TO BATTERY NEGATIVE TERMINAL

19. DISABLE BRAKE CONTROL (w/ ECB)

20. FILL RESERVOIR WITH BRAKE FLUID (w/ ECB)

21. BLEED BRAKE RESERVOIR TUBE NO.1 HOSE (w/ ECB)

22. BLEED MASTER CYLINDER (w/ ECB)

23. BLEED FRONT BRAKE SYSTEM (w/ ECB)

24. BLEED REAR BRAKE SYSTEM (w/ ECB)

25. PERFORM ACCUMULATOR ZERO DOWN (w/ ECB)

26. CHECK BRAKE FLUID LEVEL (w/ ECB)

27. CLEAR DTC (w/ ECB)

28. PERFORM LINER VALVE OFFSET LEARNING (w/ ECB)

29. FILL BRAKE FLUID (w/ VSC)

30. BLEED MASTER CYLINDER (w/ VSC)

31. BLEED BRAKE LINE (w/ VSC)

32. BLEED ABS AND TRACTION ACTUATOR ASSEMBLY (w/ VSC)

33. CHECK FLUID LEVEL IN RESERVOIR (w/ VSC)

34. INSPECT BRAKE FLUID LEAKAGE

35. INSPECT AND ADJUST BRAKE PEDAL HEIGHT

36. INSPECT PEDAL FREE PLAY

37. INSPECT PEDAL RESERVE DISTANCE

38. INSTALL DRIVER SIDE KNEE AIRBAG ASSEMBLY

39. INSTALL INSTRUMENT PANEL SAFETY PAD NO.1 SUB-ASSEMBLY

40. INSTALL INSTRUMENT PANEL UNDER COVER NO.1 SUB-ASSEMBLY

41. INSTALL INSTRUMENT SIDE PANEL LH

42. INSTALL INSTRUMENT SIDE PANEL RH

43. INSTALL FRONT DOOR OPENING TRIM COVER LH

44. INSTALL FRONT DOOR OPENING TRIM COVER RH

45. INSTALL FRONT DOOR SCUFF PLATE LH

46. INSTALL FRONT DOOR SCUFF PLATE RH

47. INSTALL INSTRUMENT PANEL FINISH PANEL END LH

48. INSTALL INSTRUMENT PANEL FINISH PANEL END RH

49. INSTALL CONSOLE UPPER PANEL SUB-ASSEMBLY

50. INSTALL CONSOLE UPPER PANEL GARNISH

51. INSTALL FRONT WHEEL

52. INSTALL COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY

53. INSTALL FRONT FENDER TO COWL SIDE SEAL RH

54. INSTALL FRONT FENDER TO COWL SIDE SEAL LH

55. INSTALL FRONT WIPER ARM AND BLADE ASSEMBLY RH

56. INSTALL FRONT WIPER ARM AND BLADE ASSEMBLY LH

57. INSTALL FRONT PILLAR TO FRONT SIDE SEAL SUB-ASSEMBLY RH

58. INSTALL FRONT PILLAR TO FRONT SIDE SEAL SUB-ASSEMBLY LH

59. INSTALL ENGINE ROOM SIDE COVER RH

60. INSTALL ENGINE ROOM SIDE COVER LH

61. INSPECT VSC SENSOR SIGNAL

62. INSPECT ACTUATOR WITH INTELLIGENT TESTER

63. INSPECT SRS WARNING LIGHT

64. PERFORM INITIALIZATION

65. CLEAR DTC