PARKING BRAKE PEDAL (for RHD) > INSTALLATION


  1. INSTALL PARKING BRAKE PEDAL

  2. INSTALL FRONT FLOOR REAR UPPER SUB PANEL

  3. INSTALL CENTER AIRBAG SENSOR ASSEMBLY

  4. INSTALL REAR PROPELLER SHAFT ASSEMBLY (for 3GR-FSE)

  5. INSPECT AND ADJUST NO. 2 AND NO. 3 JOINT ANGLE (for 3GR-FSE)

  6. INSTALL FRONT FLOOR HEAT NO.1 INSULATOR (for 3GR-FSE)

  7. INSTALL FRONT EXHAUST PIPE ASSEMBLY (for 3GR-FSE)

  8. INSTALL HEATED OXYGEN SENSOR (for 3GR-FSE)

  9. INSTALL FRONT FLOOR BRACE CENTER (for 3GR-FSE)

  10. INSTALL REAR PROPELLER SHAFT ASSEMBLY (for 3GR-FE)

  11. INSPECT AND ADJUST NO. 2 AND NO. 3 JOINT ANGLE (for 3GR-FE)

  12. INSTALL FRONT FLOOR HEAT NO.1 INSULATOR (for 3GR-FE)

  13. INSTALL FRONT EXHAUST PIPE ASSEMBLY (for 3GR-FE)

  14. INSTALL HEATED OXYGEN SENSOR (for 3GR-FE)

  15. INSTALL FRONT FLOOR BRACE CENTER (for 3GR-FE)

  16. INSTALL REAR PROPELLER SHAFT ASSEMBLY (for 3UZ-FE)

  17. FULLY TIGHTEN CENTER SUPPORT NO.1 BEARING ASSEMBLY (for 3UZ-FE)

  18. INSPECT AND ADJUST NO. 2 AND NO. 3 JOINT ANGLE (for 3UZ-FE)

  19. INSTALL FRONT FLOOR HEAT NO.1 INSULATOR (for 3UZ-FE)

  20. INSTALL FRONT EXHAUST PIPE ASSEMBLY (for 3UZ-FE)

  21. INSTALL REAR NO.1 FLOOR PANEL BRACE (for 3UZ-FE)

  22. INSTALL FRONT FLOOR BRACE CENTER (for 3UZ-FE)

  23. INSTALL AIR NO.1 DUCT

  24. INSTALL AIR NO.1 DUCT REAR

  25. INSTALL DASH PANEL INSULATOR NO.2 PAD

  26. INSTALL FRONT FLOOR SILENCER PAD

  27. INSTALL ACCELERATOR PEDAL

  28. INSTALL DRIVER SIDE KNEE AIRBAG ASSEMBLY

  29. INSTALL INSTRUMENT PANEL SAFETY NO.1 PAD SUB-ASSEMBLY

  30. INSTALL INSTRUMENT PANEL UNDER NO.1 COVER SUB-ASSEMBLY

  31. INSTALL INSTRUMENT SIDE PANEL

  32. INSTALL CONSOLE BOX

  33. INSTALL CONSOLE BOX REGISTER ASSEMBLY

  34. INSTALL CONSOLE BOX PLATE

  35. INSTALL INSTRUMENT PANEL FINISH RH PANEL END

  36. INSTALL INSTRUMENT PANEL FINISH LH PANEL END

  37. INSTALL FRONT ASH RECEPTACLE ASSEMBLY

  38. INSTALL CONSOLE UPPER PANEL GARNISH FRONT

  39. INSTALL CENTER PILLAR GARNISH LOWER

  40. INSTALL REAR DOOR SCUFF PLATE

  41. INSTALL FRONT DOOR OPENING TRIM COVER

  42. INSTALL FRONT DOOR SCUFF PLATE

  43. INSTALL AIR DUCT REAR

  44. INSTALL REAR SEAT CUSHION ASSEMBLY

  45. INSTALL FRONT SEAT ASSEMBLY

  46. INSTALL FRONT SEAT OUTER BELT ASSEMBLY

  47. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL

  48. INSPECT PARKING BRAKE PEDAL TRAVEL

  49. ADJUST PARKING BRAKE PEDAL TRAVEL

  50. PERFORM INITIALIZATION

  51. INSPECT SRS WARNING LIGHT

  52. INSPECT FRONT SEAT ASSEMBLY

  53. CHECK FOR EXHAUST GAS LEAKS