| Last Modified: 11-27-2007 | 1.6 A | |
| Service Category: Vehicle Interior | Section: Door Lock | |
| Model Year: 2008 | Model: LX570 | Doc ID: RM0000039GX003X |
| Title: DOOR LOCK: FRONT DOOR LOCK: INSTALLATION (2008 LX570) | ||
INSTALLATION
HINT:
- Use the same procedures for the LH side and RH side.
- The procedures listed below are for the LH side.
1. INSTALL FRONT DOOR INSIDE LOCKING CABLE ASSEMBLY LH
2. INSTALL FRONT DOOR LOCK REMOTE CONTROL CABLE ASSEMBLY LH
3. INSTALL FRONT DOOR LOCK ASSEMBLY LH
(a) Apply MP grease to the sliding parts of the front door lock assembly.
(b) Insert the front door lock open rod into the front door lock assembly.
(c) Make sure that the front door lock open rod is securely connected to the front door lock assembly.
(d) Using a T30 "TORX" wrench, install the door lock with the 3 screws.
Torque: 5.0 N·m (51 kgf·cm, 44 in·lbf)
4. INSTALL FRONT DOOR OUTSIDE HANDLE COVER LH
5. INSTALL FRONT DOOR REAR LOWER FRAME SUB-ASSEMBLY LH
6. INSTALL FRONT NO. 2 DOOR STIFFENER CUSHION
7. INSTALL FRONT DOOR SERVICE HOLE COVER LH
8. INSTALL DOOR TRIM COVER LH
9. INSTALL FRONT DOOR PANEL CUSHION
10. INSTALL FRONT DOOR TRIM BOARD SUB-ASSEMBLY LH
11. INSTALL COURTESY LIGHT ASSEMBLY
12. INSTALL FRONT UPPER ARMREST BASE PANEL LH
13. INSTALL FRONT DOOR INSIDE HANDLE BEZEL PLUG LH
14. INSTALL FRONT LOWER DOOR FRAME BRACKET GARNISH LH
15. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL
NOTICE:
When disconnecting the cable, some systems need to be initialized after the cable is reconnected
.
16. CHECK SRS WARNING LIGHT
(a) Check the SRS warning light
.
17. INSTALL ENGINE ROOM SIDE COVER LH
|
|