FRAME WIRE > INSTALLATION

1. INSTALL NO.3 WIRE FRAME (for LHD)

2. INSTALL NO.3 WIRE FRAME (for RHD)

3. INSTALL WIRING HARNESS PROTECTOR

4. INSTALL REAR TRACTION W/ TRANSAXLE MOTOR ASSEMBLY

5. CHECK HIGH VOLTAGE CABLE CONNECTION

6. REMOVE INVERTER COVER

7. CONNECT W/ CONVERTER INVERTER ASSEMBLY

8. CHECK HIGH VOLTAGE CABLE CONNECTION

9. INSTALL INVERTER COVER

10. INSTALL POWER STEERING ECU BRACKET

11. CONNECT INVERTER RESERVE TANK SUB-ASSEMBLY

12. INSTALL POWER STEERING ECU ASSEMBLY

13. INSTALL INVERTER BRACKET NO.5

14. INSTALL AIR CLEANER W/RESONATOR

15. INSTALL AIR CLEANER CAP W/INLET

16. INSTALL COOL AIR INTAKE DUCT SEAL

17. INSTALL COWL TOP PANEL SUB-ASSEMBLY OUTER

18. INSTALL WINDSHIELD WIPER LINK ASSEMBLY

19. INSTALL COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY

20. INSTALL FRONT WIPER ARM AND BLADE ASSEMBLY LH

21. INSTALL FRONT WIPER ARM AND BLADE ASSEMBLY RH

22. INSTALL ENGINE ROOM SIDE LH COVER

23. CONNECT HYBRID VEHICLE RELAY ASSEMBLY

24. CHECK HIGH VOLTAGE CABLE CONNECTION

25. INSTALL HYBRID VEHICLE BATTERY SERVICE HOLE COVER

26. INSTALL FLOOR CARPET ASSEMBLY FRONT

27. INSTALL AIR INTAKE COVER CENTER

28. INSTALL AIR INTAKE COVER

29. INSTALL REAR SEAT ASSEMBLY LH

30. INSTALL REAR SEAT TRACK BRACKET COVER

31. INSTALL REAR SEAT ASSEMBLY RH

32. INSTALL REAR SEAT TRACK BRACKET COVER

33. INSPECT SLIDE ADJUSTER LOCK SIMULTANEOUSLY

34. CONNECT POWER STEERING CONVERTER ASSEMBLY

35. CHECK HIGH VOLTAGE CABLE CONNECTION

36. INSTALL POWER STEERING CONVERTER COVER

37. INSTALL DECK BOARD CHECK NO.1

38. INSTALL DECK SIDE TRIM BOX RH

39. INSTALL DECK SIDE TRIM BOX LH

40. INSTALL DECK BOARD SUB-ASSEMBLY NO.3

41. INSTALL DECK BOARD SUB-ASSEMBLY NO.2

42. INSTALL DECK FLOOR BOX FRONT

43. INSTALL REAR FLOOR FINISH PLATE

44. INSTALL DECK FLOOR BOX REAR

45. INSTALL DECK BOARD SUB-ASSEMBLY

46. INSTALL SERVICE PLUG GRIP

47. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL

48. PERFORM INITIALIZATION