SPECIFICATIONS
A/C SYSTEM
| Item |
Description |
Notes |
| A/C Compressor |
Denso 10S17 |
ND-8 PAG oil |
| Freeze–up Control |
Evaporator Temperature Sensor |
HVAC housing mounted (front) |
| Low psi Control |
A/C Pressure Transducer |
A/C Discharge line mounted - opens below 110 kPa (16 psi), closes above 221kPa (32 psi) |
| High psi Control |
A/C Pressure Transducer |
A/C Discharge line mounted - opens above 3219 kPa (476 psi), closed below 2937 kPa (426 psi) |
| R-134a Refrigerant Charge Capacity |
Single Unit 0.68 kg (1.5 lbs.) Dual Unit 0.963 kg (2.125 lbs.) |
Also see A/C Underhood Specification Label located in the engine compartment |
| A/C Clutch Coil Draw |
3.3 amps |
@ 12V ± 0.5V @ 21° C (70° F) |
| A/C Clutch Coil Resistance |
3.6 ± 0.2 ohms |
When measured across coil lead connector |
| A/C Clutch Air Gap |
0.35 - 0.60 mm (0.014 - 0.024 in.) |
TORQUE
| Description |
N·m |
Ft. Lbs. |
In. Lbs. |
| All Screws NOT Listed Below |
2 |
— |
17 |
| A/C Compressor to 3.7L/4.7L Engine Bolt (#3) |
40 |
30 |
— |
| A/C Compressor to 3.7L/4.7L Engine Bolts (except #3) |
55 |
41 |
— |
| A/C Compressor to 5.7L Engine Bolts |
55 |
41 |
— |
| A/C Condenser to Radiator Bolts |
5 |
— |
44 |
| Compressor Shaft Bolt |
19 |
— |
168 |
| Front A/C Expansion Valve to Evaporator Tube Tapping Block Bolts |
11 |
— |
97 |
| Front Air Distribution Housing Halves Screws |
2.2 |
— |
20 |
| Front Air Distribution Housing to HVAC Housing Screws |
2.2 |
— |
20 |
| Front Blower Motor Screws |
2.2 |
— |
20 |
| Front HVAC Housing Halves Screws |
2.2 |
— |
20 |
| Front HVAC Housing to Dash Panel Bolts/Nut |
7 |
— |
62 |
| Front Heater Core and Tube Cover to HVAC Housing Screws |
2.2 |
— |
20 |
| Front Heater Core Tubes to Heater Core Bolt |
3 |
— |
27 |
| Front Heater Core Tube Retaining Bracket to HVAC Housing Screw |
2.2 |
— |
20 |
| Liquid Line Extension Tube to Underbody Liquid Line Nut |
20 |
15 |
— |
| Rear A/C Expansion Valve to Rear Evaporator Tube Tapping Block Bolts |
11 |
— |
97 |
| Rear HVAC Housing to Rear Quarter Panel Nut and Bolt |
3 |
— |
27 |
| Refrigerant Lines to Front A/C Expansion Valve Nut |
23 |
17 |
— |
| Refrigerant Lines to A/C Compressor Nuts |
20 |
15 |
— |
| Refrigerant Lines to A/C Condenser Nuts |
20 |
15 |
— |
| Refrigerant Line to Receiver/drier Nut |
20 |
15 |
— |
| Receiver/drier to Radiator/fan Shroud Screw |
5 |
— |
44 |
| Suction Line Extension Tube to Underbody Suction Line Nut |
20 |
15 |
— |
| Underbody Refrigerant Lines to Rear A/C Expansion Valve Nut |
23 |
17 |
— |