Check the engine oil level about 5 minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
Check the windshield washer solvent and add if required.
Once a Month
Check tire pressure and look for unusual wear or damage.
Inspect the battery and clean and tighten the terminals as required.
Check the fluid levels of coolant reservoir, brake master cylinder, power steering and transmission and add as needed.
Check all lights and other electrical items for correct operation.
At Each Oil Change
Change the engine oil filter.
Inspect the brake hoses and lines.
Check the manual transmission fluid level.
CAUTION:
Failure to perform
the required maintenance items may result in damage to the vehicle.
Proper operation
of four-wheel drive vehicles depends on tires of equal size, type
and circumference on each wheel. Any difference in tire size can cause
damage to the transfer case. Tire rotation schedule should be followed
to balance tire wear.
Oil Change Indicator System
The Scheduled Maintenance services listed in this manual must be done at the times or mileages specified to protect your vehicle warranty and ensure the best vehicle performance and reliability. More frequent maintenance may be needed for vehicles in severe operating conditions, such as dusty areas and very short trip driving. Inspection and service should also be done anytime a malfunction is suspected.
The oil change indicator system will remind you that it is time to take your vehicle in for scheduled maintenance.
On Non-EVIC equipped vehicles, “CHAngE OIL” will flash in the instrument cluster odometer and a single chime will sound, indicating that an oil change is necessary.
Based on engine operation conditions the oil change indicator message will illuminate, this means that service is required for your vehicle. Have your vehicle serviced as soon as possible, within the next 500 miles (805 km).
NOTE:
The oil change indicator message will not monitor the time since the last oil change. Change your vehicle's oil if it has been six months since your last oil change even if the oil change indicator message is NOT illuminated.
Change your engine oil more often if you drive your vehicle off-road for an extended period of time.
Under no circumstances should oil change intervals exceed 8,000 miles (13 000 km) or six months, whichever comes first.
Oil Change Indicator- Reset
The vehicle is equipped with an engine oil change indicator system. The “Oil Change Required” message flashes in the EVIC display for approximately ten seconds after a single chime has sounded, to indicate the next scheduled oil change interval. The engine oil change indicator system is duty cycle based, which means the engine oil change interval may fluctuate depending upon your personal driving style.
Unless reset, this message continues to display each time you turn the ignition switch to the ON/RUN position. To turn off the message temporarily, press and release the Menu button. To reset the oil change indicator system (after performing the scheduled maintenance) perform the following procedure:
Turn the ignition switch to the “ON” position. Do not start the engine.
Fully press the accelerator pedal slowly three times within ten seconds.
Turn the ignition switch to the “LOCK” position.
NOTE:
If the indicator message illuminates when you start the vehicle, the oil change indicator system did not reset. If necessary, repeat this procedure.
Required Maintenance Intervals
Perform Maintenance Every
Maintenance Items
(Where time and mileage are listed, follow the interval that occurs first.)
Miles
Kilometers
Months
8000
13000
6
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 8,000 miles (13 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
16000
26000
12
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 16,000 miles (26 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter; replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system. Perform the first inspection at 16,000 miles (26 000 km) or 12 months.
Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
24000
39000
18
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 24,000 miles (39 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
Inspect the CV joints.
Inspect exhaust system.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
32000
52000
24
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 32,000 miles (52 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the transfer case fluid.
Inspect the brake linings, replace if necessary.
Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
40000
65000
30
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 40,000 miles (65 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
48000
78000
36
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 48,000 miles (78 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter; replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the CV joints.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
56000
91000
42
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 56,000 miles (91 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
64000
104000
48
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 64,000 miles (104 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings; replace if necessary.
Change the automatic transmission fluid and filter if using your vehicle for any of the following: police, taxi, fleet, or frequent trailer towing.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, or frequent trailer towing.
Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
72000
117000
54
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 72,000 miles (117 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
Inspect the CV joints.
Inspect exhaust system.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
80000
130000
60
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 80,000 miles (130 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter; replace if necessary.
Flush and replace the engine coolant if not done at 104,000 miles (169 000 km).
Inspect the brake linings, replace if necessary.
Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
88000
143000
66
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 88,000 miles (143 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
96000
156000
72
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 96,000 miles (156 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Replace the ignition cables.
Replace the spark plugs.
Inspect and replace PCV valve if necessary.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the transfer case fluid.
Inspect the brake linings, replace if necessary.
Inspect the CV joints.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
104000
169000
78
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 104,000 miles (169 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
Flush and replace engine coolant at 104,000 miles (169,00 km) or 60 months (whichever occurs first).
112000
182000
84
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 112,000 miles (182 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter; replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
120000
195000
90
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 120,000 miles (195 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
Inspect the CV joints.
Inspect exhaust system.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the automatic transmission fluid and filter(s).
Replace the accessory drive belt(s).
128000
208000
96
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 128,000 miles (208 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, or frequent trailer towing.
Inspect the brake linings, replace if necessary.
Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
136000
221000
102
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 136,000 miles (221 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
144000
234000
108
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 144,000 miles (234 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter; replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the CV joints.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
152000
247000
114
Change the engine oil and engine oil filter.
Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 152,000 miles (247 000 km).
Inspect all door latches for presence of grease, reapply if necessary.
WARNING:
You can be badly
injured working on or around a motor vehicle. Do only service work
for which you have the knowledge and the right equipment. If you have
any doubt about your ability to perform a service job, take your vehicle
to a competent mechanic.
Failure to properly
inspect and maintain your vehicle could result in a component malfunction
and effect vehicle handling and performance. This could cause an accident
Failure to follow these instructions may result in possible
serious or fatal injury.
MAINTENANCE SCHEDULES - CHINA
MAINTENANCE
SCHEDULES - CHINA
Oil Change Indicator System
The Scheduled Maintenance services listed in this manual must be done at the times or mileages specified to protect your vehicle warranty and ensure the best vehicle performance and reliability. More frequent maintenance may be needed for vehicles in severe operating conditions, such as dusty areas and very short trip driving. Inspection and service should also be done anytime a malfunction is suspected.
The oil change indicator system will remind you that it is time to take your vehicle in for scheduled maintenance.
On Non-EVIC equipped vehicles, “CHAngE OIL” will flash in the instrument cluster odometer and a single chime will sound, indicating that an oil change is necessary.
The oil change indicator message will illuminate approximately 11 200 km after the most recent oil change was performed. Have your vehicle serviced as soon as possible, within 800 km. However, an earlier oil change at 5 000 km may be required if the vehicle is operated under “Severe Duty Conditions” later in this section.
NOTE:
The oil change indicator message will not monitor the time since the last oil change. Change your vehicle's oil if it has been six months since your last oil change even if the oil change indicator message is NOT illuminated.
Change your engine oil more often if you drive your vehicle off-road for an extended period of time.
Under no circumstances should oil change intervals exceed 12 000 km or six months, whichever comes first.
Oil Change Indicator-
Reset
The vehicle is equipped with an engine oil change indicator system.
The “Oil Change Required” message flashes in the EVIC display for
approximately ten seconds after a single chime has sounded, to indicate
the next scheduled oil change interval. The engine oil change indicator
system is duty cycle based, which means the engine oil change interval
may fluctuate depending upon your personal driving style.
Unless reset, this message continues to display each time you turn
the ignition switch to the ON/RUN position. To turn off the message
temporarily, press and release the Menu button. To reset the oil change
indicator system (after performing the scheduled maintenance) perform
the following procedure:
Turn the ignition switch
to the “ON” position. Do not start the engine.
Fully press the accelerator
pedal slowly three times within ten seconds.
Turn the ignition switch
to the “LOCK” position.
NOTE:
If the indicator message
illuminates when you start the vehicle, the oil change indicator system
did not reset. If necessary, repeat this procedure.
At Each Stop
for Fuel
Check the engine oil
level about 5 minutes after a fully warmed engine is shut off. Checking
the oil level while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when the level is
at or below the ADD or MIN mark.
Check the windshield
washer solvent and add if required.
Once a Month
Check tire pressure
and look for unusual wear or damage.
Inspect the battery
and clean and tighten the terminals as required.
Check the fluid levels
of coolant reservoir, brake master cylinder, power steering and transmission
and add as needed.
Check all lights and
other electrical items for correct operation.
At Each Oil
Change
Change the engine oil
filter.
Inspect the brake hoses
and lines.
CAUTION:
Failure to perform
the required maintenance items may result in damage to the vehicle.
Proper operation
of four-wheel drive vehicles depends on tires of equal size, type
and circumference on each wheel. Any difference in tire size can cause
damage to the transfer case. Tire rotation schedule should be followed
to balance tire wear.
Required Maintenance Intervals
Perform Maintenance Every
Maintenance Items
(Where time and mileage are listed, follow the interval that occurs first.)
Miles
Kilometers
Months
7500
12000
6
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
15000
24000
12
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect exhaust system. Perform the first inspection at 24 000 km or 12 months.
22500
36000
18
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect the CV joints.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
30000
48000
24
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect the transfer case fluid.
37500
60000
30
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
45000
72000
36
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
52500
84000
42
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
60000
96000
48
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the automatic transmission fluid and filter if using your vehicle for any of the following: police, taxi, fleet or frequent trailer towing.
Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road or frequent trailer towing.
67500
108000
54
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
75000
120000
60
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
82500
132000
66
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
90000
144000
72
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Inspect and replace PCV valve if necessary.†
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
Inspect the transfer case fluid.
97500
156000
78
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the spark plugs.
Flush and replace engine coolant.
105000
168000
84
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
112500
180000
90
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
120000
192000
96
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the automatic transmission fluid and filter.
Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road or frequent trailer towing.
Replace accessory drive belt(s).
127500
204000
102
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
135000
216000
108
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
142500
228000
114
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
150000
240000
120
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect the transfer case fluid.
† This maintenance is recommended by the manufacturer to the owner, but is not required to maintain emissions warranty.
WARNING:
You can be badly
injured working on or around a motor vehicle. Do only service work
for which you have the knowledge and the right equipment. If you have
any doubt about your ability to perform a service job, take your vehicle
to a competent mechanic.
Failure to properly
inspect and maintain your vehicle could result in a component malfunction
and effect vehicle handling and performance. This could cause an accident
Failure to follow these instructions may result in possible
serious or fatal injury.
Severe Duty Conditions
†† Change the engine oil and engine oil filter at every 5 000 km or three months if using your vehicle under any of the following severe duty conditions:
Stop and go driving.
Driving in dusty conditions.
Short trips of less than 16 km.
Trailer towing.
Taxi, police, or delivery service (commercial service).
Off-road or desert operation.
MAINTENANCE SCHEDULES - EUROPE
MAINTENANCE SCHEDULES - EUROPE
At Each Stop for Fuel
Check the engine oil level about 5 minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
Check the windshield washer solvent and add if required.
Once a Month
Check tire pressure and look for unusual wear or damage.
Inspect the battery and clean and tighten the terminals as required.
Check the fluid levels of the coolant reservoir, brake master cylinder, power steering and transmission (4.7L and 5.7L only) and add as needed.
Check all lights and other electrical items for correct operation.
At Each Oil Change
Change the engine oil filter.
Inspect the brake hoses and lines.
CAUTION:
Failure to perform the required
maintenance items may result in damage to the vehicle.
Maintenance Schedule – Gasoline Engine
The oil change indicator system will remind you that it is time to take your vehicle in for scheduled maintenance.
On Non-EVIC equipped vehicles, “CHANgE OIL” will flash in the instrument cluster odometer and a single chime will sound, indicating that an oil change is necessary.
The oil change indicator message will illuminate approximately 7,000 miles (11 200 km) after the most recent oil change was performed. Have your vehicle serviced as soon as possible, within 500 miles (800 km). However, an earlier oil change at 3,000 miles (5 000 km) may be required if the vehicle is operated under “Severe Duty Conditions” later in this section.
NOTE:
The oil change indicator message will not monitor the time since the last oil change. Change your vehicles oil if it has been 6 months since your last oil change even if the oil change indicator message is NOT illuminated.
Change your engine oil more often if you drive your vehicle off-road for an extended period of time.
Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or 6 months, whichever comes first.
Oil Change Indicator- Reset
The vehicle is equipped with an engine oil change indicator system. The “Oil Change Required” message flashes in the EVIC display for approximately ten seconds after a single chime has sounded, to indicate the next scheduled oil change interval. The engine oil change indicator system is duty cycle based, which means the engine oil change interval may fluctuate depending upon your personal driving style.
Unless reset, this message continues to display each time you turn the ignition switch to the ON/RUN position. To turn off the message temporarily, press and release the Menu button. To reset the oil change indicator system (after performing the scheduled maintenance) perform the following procedure:
Turn the ignition switch to the “ON” position. Do not start the engine.
Fully press the accelerator pedal slowly three times within ten seconds.
Turn the ignition switch to the “LOCK” position.
NOTE:
If the indicator message illuminates when you start the vehicle, the oil change indicator system did not reset. If necessary, repeat this procedure.
Required Maintenance Intervals
Perform Maintenance Every
Maintenance Items
(Where time and mileage are listed, follow the interval that occurs first.)
Miles
Kilometers
Months
7500
12000
6
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
15000
24000
12
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
22500
36000
18
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
30000
48000
24
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front and rear axle fluid. Change if using your vehicle for police, taxi, fleet, or frequent trailer towing.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Inspect the transfer case fluid.
37500
60000
30
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
45000
72000
36
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
52500
84000
42
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
60000
96000
48
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the front and rear axle fluid. Change if using your vehicle for police, taxi, fleet, or frequent trailer towing.
Inspect the brake linings, replace if necessary.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Change the automatic transmission fluid and filter if using your vehicle for any of the following: police, taxi, fleet or frequent trailer towing.
Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road or frequent trailer towing.
67500
108000
54
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
75000
120000
60
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect the brake linings, replace if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Flush and replace the engine coolant at 60 months if not done at 105,000 miles (168 000 km).
82500
132000
66
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
90000
144000
72
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Inspect and replace PCV valve if necessary.†
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the front and rear axle fluid. Change if using your vehicle for police, taxi, fleet, or frequent trailer towing.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Inspect the transfer case fluid.
97500
156000
78
Change the engine oil and engine oil filter.††
Rotate tires.
Replace the spark plugs.
Inspect all door latches for presence of grease, reapply if necessary.
105000
168000
84
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Flush and replace the engine coolant if not done at 60 months.
112500
180000
90
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
120000
192000
96
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Replace accessory drive belt(s).
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road or frequent trailer towing.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Change the automatic transmission fluid, and filter.
127500
204000
102
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
135000
216000
108
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
142500
228000
114
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
150000
240000
120
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Inspect the transfer case fluid.
† This maintenance is recommended by the manufacturer to the owner, but is not required to maintain emissions warranty.
WARNING:
Failure to properly
inspect and maintain the vehicle could result in a component malfunction
and effect vehicle handling and performance. This could cause an accident
and may result in possible serious or fatal injury.
Severe Duty Conditions
†† Change the engine oil and engine oil filter at every 3,000 miles (5 000 km) or 3 months if using your vehicle under any of the following severe duty conditions:
Stop and go driving.
Driving in dusty conditions.
Short trips of less than 10 miles (16 km).
Trailer towing.
Taxi, police, or delivery service (commercial service).
Off-road or desert operation.
Maintenance Schedule – Diesel Engine
At Each Stop for Fuel
Check the engine oil level about five minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
Check the windshield washer solvent, add as required.
Once a Month
Check the tire pressure and look for unusual wear or damage.
Inspect the battery; clean and tighten the terminals as required.
Check the fluid levels of engine coolant/antifreeze deaeration bottle, and brake master cylinder, add as needed.
Check all lights and all other electrical items for correct operation.
At Each Oil Change
Change the engine oil filter.
Inspect the exhaust system.
Inspect brake hoses.
Check the engine coolant/antifreeze level, hoses, and clamps.
Inspect engine accessory drive belts. Replace as necessary.
Inspect for the presence of water in the fuel filter/water separator unit.
CAUTION:
Failure to perform the required
maintenance items may result in damage to the vehicle.
Perform Maintenance Every
Maintenance Items
(Where time and mileage are listed, follow the interval that occurs first.)
Miles
Kilometers
Months
15000
25000
12
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle in dusty or off-road conditions, inspect the engine air cleaner filter, and replace if necessary.
Drain the fuel filter/water separator unit.
Inspect the brake linings, replace if necessary.
30000
50000
24
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Drain the fuel filter/water separator unit.
Replace the fuel filter.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect the transfer case fluid.
Inspect the brake linings, replace if necessary.
45000
75000
36
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle in dusty or off-road conditions, inspect the engine air cleaner filter, and replace if necessary.
Drain the fuel filter/water separator unit.
Inspect the brake linings, replace if necessary.
60000
100000
48
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Drain the fuel filter/water separator unit.
Replace the fuel filter.
Replace the engine accessory drive belt.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the transfer case fluid if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect the brake linings, replace if necessary.
Inspect the manual transmission fluid, add as necessary.
Change the automatic transmission fluid and filter if using the vehicle for any of the following; police, taxi, fleet or frequent trailer towing.
75000
125000
60
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle in dusty or off-road conditions, inspect the engine air cleaner filter, and replace if necessary.
Drain the fuel filter/water separator unit.
Inspect the brake linings, replace if necessary.
90000
150000
72
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Drain the fuel filter/water separator unit.
Replace the fuel filter.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect the transfer case fluid.
Inspect the brake linings, replace if necessary.
105000
175000
84
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle in dusty or off-road conditions, inspect the engine air cleaner filter, and replace if necessary.
Drain the fuel filter/water separator unit.
Inspect the brake linings, replace if necessary.
Flush and replace the engine coolant (antifreeze).
120000
200000
96
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Drain the fuel filter/water separator unit.
Replace the fuel filter.
Replace the engine accessory drive belt.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the transfer case if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect the brake linings, replace if necessary.
Inspect the manual transmission fluid, add as necessary.
Change the automatic transmission fluid and filter.
Replace the engine timing belt, and timing belt tensioner.
135000
225000
108
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle in dusty or off-road conditions, inspect the engine air cleaner filter, and replace if necessary.
Drain the fuel filter/water separator unit.
Inspect the brake linings, replace if necessary.
150000
250000
120
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Drain the fuel filter/water separator unit.
Replace the fuel filter.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect the transfer case fluid.
Inspect the brake linings, replace if necessary.
WARNING:
Failure to properly
inspect and maintain the vehicle could result in a component malfunction
and effect vehicle handling and performance. This could cause an accident
and may result in possible serious or fatal injury.
Diesel Models with Diesel Particulate Filter (DPF)
The oil change indicator system will remind you that it is time to take your vehicle in for scheduled maintenance.
A “CHANgE OIL” message will flash in the instrument cluster odometer and a single chime will sound, indicating that an oil change is necessary.
Based on engine operation conditions, the oil change indicator message will illuminate, this means that service is required for your vehicle. Have your vehicle serviced as soon as possible, within the next 500 miles (805 km).
OIL CHANGE INDICATOR - RESET
The vehicle is equipped with an engine oil change indicator system. The “Oil Change Required” message will flash in the EVIC display for approximately 10 seconds after a single chime has sounded to indicate the next scheduled oil change interval. The engine oil change indicator system is duty cycle based, which means the engine oil change interval may fluctuate dependent upon your personal driving style.
Unless reset, this message will continue to display each time you turn the ignition switch to the ON/RUN position. To turn off the message temporarily, press and release the Menu button. To reset the oil change indicator system (after performing the scheduled maintenance) perform the following procedure:
Turn the ignition switch to the “ON” position (Do not start the engine).
Fully depress the accelerator pedal and keep it fully pressed for at least 30 seconds.
Press and release the brake pedal six times while holding the accelerator pedal pressed.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following pages for the required maintenance intervals.
NOTE:
Under no circumstances should oil change intervals exceed 15,000 miles (25 000 km) or 12 months, whichever comes first.
MAINTENANCE SCHEDULES - UK
MAINTENANCE
SCHEDULES - UK
Maintenance
Schedule – Gasoline Engine
The oil change indicator system will remind you that it is time
to take your vehicle in for scheduled maintenance.
On Non-EVIC equipped vehicles, “CHANgE OIL” will flash in the instrument
cluster odometer and a single chime will sound, indicating that an
oil change is necessary.
The oil change indicator message will illuminate approximately
7,000 miles (11 200 km) after the most recent oil change was performed.
Have your vehicle serviced as soon as possible, within 500 miles (800
km). However, an earlier oil change at 4,500 miles (7 500 km) may
be required if the vehicle is operated under “Severe Duty Conditions”
later in this section.
NOTE:
The oil change indicator
message will not monitor the time since the last oil change. Change
your vehicles oil if it has been 6 months since your last oil change
even if the oil change indicator message is NOT illuminated.
Change your engine
oil more often if you drive your vehicle off-road for an extended
period of time.
Under no circumstances
should oil change intervals exceed 7,500 miles (12 000 km) or 6 months,
whichever comes first.
At Each Stop
for Fuel
Check the engine oil
level about 5 minutes after a fully warmed engine is shut off. Checking
the oil level while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when the level is
at or below the ADD or MIN mark.
Check the windshield
washer solvent and add if required.
Once a Month
Check tire pressure
and look for unusual wear or damage.
Inspect the battery
and clean and tighten the terminals as required.
Check the fluid levels
of the coolant reservoir, brake master cylinder, power steering and
transmission (4.7L and 5.7L only) and add as needed.
Check all lights and
other electrical items for correct operation.
At Each Oil
Change
Change the engine oil
filter.
Inspect the brake hoses
and lines.
CAUTION:
Failure to perform
the required maintenance items may result in damage to the vehicle.
Proper operation
of four-wheel drive vehicles depends on tires of equal size, type
and circumference on each wheel. Any difference in tire size can cause
damage to the transfer case. Tire rotation schedule should be followed
to balance tire wear.
Oil Change Indicator- Reset
The vehicle is equipped with an engine oil change indicator system. The “Oil Change Required” message flashes in the EVIC display for approximately ten seconds after a single chime has sounded, to indicate the next scheduled oil change interval. The engine oil change indicator system is duty cycle based, which means the engine oil change interval may fluctuate depending upon your personal driving style.
Unless reset, this message continues to display each time you turn the ignition switch to the ON/RUN position. To turn off the message temporarily, press and release the Menu button. To reset the oil change indicator system (after performing the scheduled maintenance) perform the following procedure:
Turn the ignition switch to the “ON” position. Do not start the engine.
Fully press the accelerator pedal slowly three times within ten seconds.
Turn the ignition switch to the “LOCK” position.
NOTE:
If the indicator message illuminates when you start the vehicle, the oil change indicator system did not reset. If necessary, repeat this procedure.
Required Maintenance Intervals
Perform Maintenance Every
Maintenance Items
(Where time and mileage are listed, follow the interval that occurs first.)
Miles
Kilometers
Months
7500
12000
6
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
15000
24000
12
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
22500
36000
18
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
30000
48000
24
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front and rear axle fluid. Change if using your vehicle for police, taxi, fleet, or frequent trailer towing.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Inspect the transfer case fluid.
37500
60000
30
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
45000
72000
36
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
52500
84000
42
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
60000
96000
48
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the front and rear axle fluid. Change if using your vehicle for police, taxi, fleet, or frequent trailer towing.
Inspect the brake linings, replace if necessary.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Change the automatic transmission fluid and filter if using your vehicle for any of the following: police, taxi, fleet or frequent trailer towing.
Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road or frequent trailer towing.
67500
108000
54
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
75000
120000
60
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect the brake linings, replace if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Flush and replace the engine coolant at 60 months if not done at 105,000 miles (168 000 km).
82500
132000
66
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
90000
144000
72
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Inspect and replace PCV valve if necessary.†
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the front and rear axle fluid. Change if using your vehicle for police, taxi, fleet, or frequent trailer towing.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Inspect the transfer case fluid.
97500
156000
78
Change the engine oil and engine oil filter.††
Rotate tires.
Replace the spark plugs.
Inspect all door latches for presence of grease, reapply if necessary.
105000
168000
84
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Flush and replace the engine coolant if not done at 60 months.
112500
180000
90
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
120000
192000
96
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Replace accessory drive belt(s).
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road or frequent trailer towing.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Change the automatic transmission fluid, and filter.
127500
204000
102
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
135000
216000
108
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
142500
228000
114
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
150000
240000
120
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Inspect the transfer case fluid.
WARNING:
You can be badly
injured working on or around a motor vehicle. Do only service work
for which you have the knowledge and the right equipment. If you have
any doubt about your ability to perform a service job, take your vehicle
to a competent mechanic.
Failure to properly
inspect and maintain your vehicle could result in a component malfunction
and effect vehicle handling and performance. This could cause an accident
Failure to follow these instructions may result in possible
serious or fatal injury.
Severe Duty Conditions
†† Change the engine oil and engine oil filter at every 3,000 miles (5 000 km) or 3 months if using your vehicle under any of the following severe duty conditions:
Stop and go driving.
Driving in dusty conditions.
Short trips of less than 10 miles (16 km).
Trailer towing.
Taxi, police, or delivery service (commercial service).
Off-road or desert operation.
Maintenance
Schedule – Diesel Engine
At Each Stop
for Fuel
Check the engine oil
level about five minutes after a fully warmed engine is shut off.
Checking the oil level while the vehicle is on level ground will improve
the accuracy of the oil level reading. Add oil only when the level
is at or below the ADD or MIN mark.
Check the windshield
washer solvent, add as required.
Once a Month
Check the tire pressure
and look for unusual wear or damage.
Inspect the battery;
clean and tighten the terminals as required.
Check the fluid levels
of engine coolant/antifreeze deaeration bottle, and brake master cylinder,
add as needed.
Check all lights and
all other electrical items for correct operation.
At Each Oil
Change
Change the engine oil
filter.
Inspect the exhaust
system.
Inspect brake hoses.
Check the engine coolant/antifreeze
level, hoses, and clamps.
Inspect engine accessory
drive belts. Replace as necessary.
Inspect for the presence
of water in the fuel filter/water separator unit.
CAUTION:
Failure to perform the required
maintenance items may result in damage to the vehicle.
WARNING:
Failure to properly
inspect and maintain the vehicle could result in a component malfunction
and effect vehicle handling and performance. This could cause an accident
and may result in possible serious or fatal injury.
Diesel Models with Diesel Particulate Filter (DPF)
The oil change indicator system will remind you that it is time to take your vehicle in for scheduled maintenance.
A “CHANgE OIL” message will flash in the instrument cluster odometer and a single chime will sound, indicating that an oil change is necessary.
Based on engine operation conditions, the oil change indicator message will illuminate, this means that service is required for your vehicle. Have your vehicle serviced as soon as possible, within the next 500 miles (805 km).
OIL CHANGE INDICATOR - RESET
The vehicle is equipped with an engine oil change indicator system. The “Oil Change Required” message will flash in the EVIC display for approximately 10 seconds after a single chime has sounded to indicate the next scheduled oil change interval. The engine oil change indicator system is duty cycle based, which means the engine oil change interval may fluctuate dependent upon your personal driving style.
Unless reset, this message will continue to display each time you turn the ignition switch to the ON/RUN position. To turn off the message temporarily, press and release the Menu button. To reset the oil change indicator system (after performing the scheduled maintenance) perform the following procedure:
Turn the ignition switch to the “ON” position (Do not start the engine).
Fully depress the accelerator pedal and keep it fully pressed for at least 30 seconds.
Press and release the brake pedal six times while holding the accelerator pedal pressed.
Required Maintenance
Intervals
NOTE:
Under no circumstances
should oil change intervals exceed 15,000 miles (25 000 km) or 12
months, whichever comes first.
Perform Maintenance Every
Maintenance Items
(Where time and mileage are listed, follow the interval that occurs first.)
Miles
Kilometers
Months
15000
25000
12
Change the
engine oil and engine oil filter.††
Rotate tires.
Inspect all
door latches for presence of grease, reapply if necessary.
If using your
vehicle in dusty or off-road conditions, inspect the engine air cleaner
filter, and replace if necessary.
Drain the
fuel filter/water separator unit.
Inspect the
brake linings, replace if necessary.
30000
50000
24
Change the
engine oil and engine oil filter.††
Rotate tires.
Inspect all
door latches for presence of grease, reapply if necessary.
Replace engine
air cleaner filter.
Adjust parking
brake on vehicles equipped with four-wheel disc brakes.
Drain the
fuel filter/water separator unit.
Replace the
fuel filter.
Inspect the
front and rear axle fluid, change if using your vehicle for police,
taxi, fleet, off-road or frequent trailer towing.
Inspect the
transfer case fluid.
Inspect the
brake linings, replace if necessary.
45000
75000
36
Change the
engine oil and engine oil filter.††
Rotate tires.
Inspect all
door latches for presence of grease, reapply if necessary.
If using your
vehicle in dusty or off-road conditions, inspect the engine air cleaner
filter, and replace if necessary.
Drain the
fuel filter/water separator unit.
Inspect the
brake linings, replace if necessary.
60000
100000
48
Change the
engine oil and engine oil filter.††
Rotate tires.
Inspect all
door latches for presence of grease, reapply if necessary.
Replace engine
air cleaner filter.
Adjust parking
brake on vehicles equipped with four-wheel disc brakes.
Drain the
fuel filter/water separator unit.
Replace the
fuel filter.
Replace the
engine accessory drive belt.
Inspect the
front and rear axle fluid, change if using your vehicle for police,
taxi, fleet, off-road or frequent trailer towing.
Change the
transfer case fluid if using your vehicle for police, taxi, fleet,
off-road or frequent trailer towing.
Inspect the
brake linings, replace if necessary.
Inspect the
manual transmission fluid, add as necessary.
Change the
automatic transmission fluid and filter if using the vehicle for any
of the following; police, taxi, fleet or frequent trailer towing.
75000
125000
60
Change the
engine oil and engine oil filter.††
Rotate tires.
Inspect all
door latches for presence of grease, reapply if necessary.
If using your
vehicle in dusty or off-road conditions, inspect the engine air cleaner
filter, and replace if necessary.
Drain the
fuel filter/water separator unit.
Inspect the
brake linings, replace if necessary.
90000
150000
72
Change the
engine oil and engine oil filter.††
Rotate tires.
Inspect all
door latches for presence of grease, reapply if necessary.
Replace engine
air cleaner filter.
Adjust parking
brake on vehicles equipped with four-wheel disc brakes.
Drain the
fuel filter/water separator unit.
Replace the
fuel filter.
Inspect the
front and rear axle fluid, change if using your vehicle for police,
taxi, fleet, off-road or frequent trailer towing.
Inspect the
transfer case fluid.
Inspect the
brake linings, replace if necessary.
105000
175000
84
Change the
engine oil and engine oil filter.††
Rotate tires.
Inspect all
door latches for presence of grease, reapply if necessary.
If using your
vehicle in dusty or off-road conditions, inspect the engine air cleaner
filter, and replace if necessary.
Drain the
fuel filter/water separator unit.
Inspect the
brake linings, replace if necessary.
Flush and
replace the engine coolant (antifreeze).
120000
200000
96
Change the
engine oil and engine oil filter.††
Rotate tires.
Inspect all
door latches for presence of grease, reapply if necessary.
Replace engine
air cleaner filter.
Adjust parking
brake on vehicles equipped with four-wheel disc brakes.
Drain the
fuel filter/water separator unit.
Replace the
fuel filter.
Replace the
engine accessory drive belt.
Inspect the
front and rear axle fluid, change if using your vehicle for police,
taxi, fleet, off-road or frequent trailer towing.
Change the
transfer case if using your vehicle for police, taxi, fleet, off-road
or frequent trailer towing.
Inspect the
brake linings, replace if necessary.
Inspect the
manual transmission fluid, add as necessary.
Change the
automatic transmission fluid and filter.
Replace the
engine timing belt, and timing belt tensioner.
135000
225000
108
Change the
engine oil and engine oil filter.††
Rotate tires.
Inspect all
door latches for presence of grease, reapply if necessary.
If using your
vehicle in dusty or off-road conditions, inspect the engine air cleaner
filter, and replace if necessary.
Drain the
fuel filter/water separator unit.
Inspect the
brake linings, replace if necessary.
150000
250000
120
Change the
engine oil and engine oil filter.††
Rotate tires.
Inspect all
door latches for presence of grease, reapply if necessary.
Replace engine
air cleaner filter.
Adjust parking
brake on vehicles equipped with four-wheel disc brakes.
Drain the
fuel filter/water separator unit.
Replace the
fuel filter.
Inspect the
front and rear axle fluid, change if using your vehicle for police,
taxi, fleet, off-road or frequent trailer towing.
Inspect the
transfer case fluid.
Inspect the
brake linings, replace if necessary.
MAINTENANCE SCHEDULES - MIDDLE EAST
MAINTENANCE SCHEDULES - MIDDLE EAST
At Each Stop for Fuel
Check the engine oil level about 5 minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
Check the windshield washer solvent and add if required.
At Each Stop for Fuel
Check the engine oil level about five minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
Check the windshield washer solvent and add if required.
Once a Month
Check tire pressure and look for unusual wear or damage.
Inspect the battery and clean and tighten the terminals as required.
Check the fluid levels of coolant reservoir, brake master cylinder, power steering and automatic transmission and add as needed.
Check all lights and other electrical items for correct operation.
At Each Oil Change
Change the engine oil filter.
Inspect the brake hoses and lines.
CAUTION:
Failure to perform
the required maintenance items may result in damage to the vehicle.
Proper operation
of four-wheel drive vehicles depends on tires of equal size, type
and circumference on each wheel. Any difference in tire size can cause
damage to the transfer case. Tire rotation schedule should be followed
to balance tire wear.
Oil Change Indicator System
The oil change indicator system will remind you that it is time to take your vehicle in for scheduled maintenance.
On Non-EVIC equipped vehicles, “CHANgE OIL” will flash in the instrument cluster odometer and a single chime will sound, indicating that an oil change is necessary.
The oil change indicator message will illuminate approximately 7,000 miles (11 200 km) after the most recent oil change was performed. Have your vehicle serviced as soon as possible, within 500 miles (800 km). However, an earlier oil change at 3,000 miles (5,000 km) may be required if the vehicle is operated under “Severe Duty Conditions” later in this section.
NOTE:
The oil change indicator message will not monitor the time since the last oil change. Change your vehicle's oil if it has been six months since your last oil change even if the oil change indicator message is NOT illuminated.
Change your engine oil more often if you drive your vehicle off-road for an extended period of time.
Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first.
Oil Change Indicator- Reset
The vehicle is equipped with an engine oil change indicator system. The “Oil Change Required” message flashes in the EVIC display for approximately ten seconds after a single chime has sounded, to indicate the next scheduled oil change interval. The engine oil change indicator system is duty cycle based, which means the engine oil change interval may fluctuate depending upon your personal driving style.
Unless reset, this message continues to display each time you turn the ignition switch to the ON/RUN position. To turn off the message temporarily, press and release the Menu button. To reset the oil change indicator system (after performing the scheduled maintenance) perform the following procedure:
Turn the ignition switch to the “ON” position. Do not start the engine.
Fully press the accelerator pedal slowly three times within ten seconds.
Turn the ignition switch to the “LOCK” position.
NOTE:
If the indicator message illuminates when you start the vehicle, the oil change indicator system did not reset. If necessary, repeat this procedure.
Required Maintenance Intervals
Perform Maintenance Every
Maintenance Items
(Where time and mileage are listed, follow the interval that occurs first.)
Miles
Kilometers
Months
7500
12000
6
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
15000
24000
12
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect exhaust system. Perform the first inspection at 15,000 miles (24 000 km) or 12 months.
22500
36000
18
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
30000
48000
24
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Inspect the transfer case fluid.
37500
60000
30
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
45000
72000
36
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
52500
84000
42
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
60000
96000
48
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Change the automatic transmission fluid and filter if using your vehicle for any of the following: police, taxi, fleet or frequent trailer towing.
Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road or frequent trailer towing.
67500
108000
54
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
75000
120000
60
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
82500
132000
66
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
90000
144000
72
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Inspect and replace PCV valve if necessary.†
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Inspect the transfer case fluid.
97500
156000
78
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the spark plugs.
Flush and replace engine coolant.
105000
168000
84
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
112500
180000
90
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
120000
192000
96
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Change the automatic transmission fluid and filter.
Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road or frequent trailer towing.
Replace accessory drive belt(s).
127500
204000
102
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
135000
216000
108
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Inspect exhaust system.
Inspect the front suspension, tie rod ends and boot seals, replace if necessary.
142500
228000
114
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
150000
240000
120
Change the engine oil and engine oil filter.††
Rotate tires.
Inspect all door latches for presence of grease, reapply if necessary.
Replace the engine air cleaner filter.
Adjust parking brake on vehicles equipped with four-wheel disc brakes.
Inspect the brake linings, replace if necessary.
Inspect the front & rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Change the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police, delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot weather, above 90°F (32°C).
Inspect the transfer case fluid.
† This maintenance is recommended by the manufacturer to the owner, but is not required to maintain emissions warranty.
WARNING:
You can be badly
injured working on or around a motor vehicle. Do only service work
for which you have the knowledge and the right equipment. If you have
any doubt about your ability to perform a service job, take your vehicle
to a competent mechanic.
Failure to properly
inspect and maintain your vehicle could result in a component malfunction
and effect vehicle handling and performance. This could cause an accident
Failure to follow these instructions may result in possible
serious or fatal injury.
Severe Duty Conditions
†† Change the engine oil and engine oil filter at every 3,000 miles (5 000 km) or three months if using your vehicle under any of the following severe duty conditions:
Stop and go driving.
Driving in dusty conditions.
Short trips of less than 10 miles (16 km).
Trailer towing.
Taxi, police, or delivery service (commercial service).
Off-road or desert operation.
INSPECTION
INSPECTION
The following steps outline the dealer inspection procedure required
every 5 years for vehicles covered under the terms of the Lifetime
Powertrain Warranty. Refer to the appropriate warranty information
for additional terms and coverages applicable to the Lifetime Powertrain
Warranty.
Lift the vehicle on
a suitable hoist.
Check all Powertrain
components for leaks or physical damage. Note any concerns.
Lower the vehicle and
check the level and condition of the engine oil.
Connect a diagnostic
scan tool and check for any active Powertrain Diagnostic Trouble Codes
(DTC).