AIR CONDITIONING UNIT > INSTALLATION

1. INSTALL BLOWER ASSEMBLY

2. INSTALL WIRING AIR INDICATOR HARNESS NO.2 SUB-ASSEMBLY

3. INSTALL AIR DUCT NO.2

4. TEMPORARILY TIGHTEN AIR CONDITIONER UNIT ASSEMBLY

5. INSTALL INSTRUMENT PANEL REINFORCEMENT ASSEMBLY

6. INSTALL INSTRUMENT PANEL BRACE NO.2 SUB-ASSEMBLY

7. INSTALL INSTRUMENT PANEL BRACE NO.1 SUB-ASSEMBLY

8. INSTALL INSTRUMENT PANEL BRACKET NO.4

9. INSTALL AIR DUCT NO.1 SUB-ASSEMBLY

10. FULLY TIGHTEN AIR CONDITIONER UNIT ASSEMBLY

11. INSTALL STEERING COLUMN ASSEMBLY (Manual Tilt Type)

12. INSTALL STEERING COLUMN ASSEMBLY (Power Tilt and Power Type)

13. CONNECT STEERING INTERMEDIATE SHAFT SUB-ASSEMBLY (Manual Tilt Type)

14. CONNECT STEERING INTERMEDIATE SHAFT SUB-ASSEMBLY (Power Tilt and Power Type)

15. INSTALL AIR DUCT NO.1

16. INSTALL HYBRID VEHICLE CONTROL ECU

17. INSTALL AIR CONDITIONER AMPLIFIER ASSEMBLY

18. INSTALL SHIFT LEVER

19. CONNECT TRANSMISSION CONTROL CABLE ASSEMBLY

20. INSPECT SHIFT LEVER POSITION

21. ADJUST SHIFT LEVER POSITION

22. INSTALL AIR DUCT REAR NO.1

23. INSTALL AIR DUCT REAR NO.2

24. INSTALL INSTRUMENT PANEL ASSEMBLY

25. INSTALL HEATER WATER INLET HOSE

26. INSTALL HEATER WATER OUTLET HOSE

27. INSTALL COOLER REFRIGERANT SUCTION HOSE NO.1 (LHD Type:)

28. INSTALL COOLER REFRIGERANT SUCTION PIPE NO.1 (RHD Type:)

29. INSTALL AIR CONDITIONING TUBE AND ACCESSORY ASSEMBLY

30. INSTALL COWL TOP PANEL OUTER SUB-ASSEMBLY

31. INSTALL WINDSHIELD WIPER LINK ASSEMBLY

32. INSTALL COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY

33. INSTALL FRONT WIPER ARM AND BLADE ASSEMBLY LH

34. INSTALL FRONT WIPER ARM AND BLADE ASSEMBLY RH

35. ADD ENGINE COOLANT

36. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL

37. CHARGE WITH REFRIGERANT

38. WARM UP COMPRESSOR

39. CHECK FOR ENGINE COOLANT LEAKS

40. CHECK FOR LEAKAGE OF REFRIGERANT

41. REMOVE PERFORM INITIALIZATION