HEATER WATER PUMP > REMOVAL

1. REMOVE ENGINE ROOM SIDE LH COVER

2. REMOVE ENGINE ROOM COVER SIDE

3. DRAIN HYBRID VEHICLE COOLANT

4. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL

5. REMOVE SERVICE PLUG GRIP

6. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY RH

7. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY LH

8. REMOVE COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY

9. REMOVE WINDSHIELD WIPER MOTOR ASSEMBLY

10. REMOVE COWL TOP PANEL SUB-ASSEMBLY OUTER

11. REMOVE COOL AIR INTAKE DUCT SEAL

12. REMOVE AIR CLEANER CAP W/ INLET

13. REMOVE AIR CLEANER W/ RESONATOR

14. REMOVE INVERTER BRACKET NO.5

15. REMOVE POWER STEERING ECU ASSEMBLY

16. REMOVE CIRCUIT BREAKER SENSOR NO.1

17. REMOVE ENGINE ROOM WIRE NO.2

18. REMOVE INVERTER RESERVE TANK SUB-ASSEMBLY

19. DISCONNECT WATER HOSE

20. DISCONNECT POWER STEERING ECU BRACKET

21. REMOVE INVERTER COVER

22. VERIFY THAT VOLTAGE OF W/CONVERTER ASSEMBLY IS 0 V

23. REMOVE ENGINE WIRE NO.4

24. DISCONNECT HIGH VOLTAGE CABLE OF THE FRONT MOTOR

25. DISCONNECT MG ECU CONNECTOR

26. DISCONNECT NO.3 WIRE FRAME

27. INSTALL INVERTER COVER

28. SEPARATE ENGINE ROOM RELAY BLOCK ASSEMBLY

29. REMOVE INVERTER BRACKET NO.4

30. REMOVE W/CONVERTER INVERTER ASSEMBLY

31. REMOVE HEATER WATER PUMP ASSEMBLY