Suzuki Vitara (LY) 2016-2017 · Service Manual Scheduled Maintenance

Maintenance Schedule under Normal Driving Conditions (Market Code P02, P22 and P54)

Precautions: General safety (00)

M16A Engine Model and D16AA Engine Model
NOTE:
•For discrimination of market code, refer to Identification Plate.
•The intervals should be determined based on odometer readings or months, whichever comes first.
•The following table shows the service schedule up to 240,000 km (150,000 miles). Beyond 240,000 km (150,000 miles), perform the same maintenance services at the same intervals shown in the table.
•This table shows the typical maintenance schedule.
The actual maintenance schedule, however, varies depending on vehicle specifications, so the typical maintenance schedule may not be applicable to some models.
Therefore, for the maintenance schedule that is specifically applicable to the vehicle being serviced, follow the relevant instructions in the “Periodic Maintenance Schedule” under “INSPECTION AND MAINTENANCE” section of the Owner’s Manual.
•Class 1: M16A engine
•Class 2: D16AA engine
Interval km (x 1,000) 20 40 60 80 100 120 140 160 180 200 220 240
miles (x 1,000) 12.5 25 37.5 50 62.5 75 87.5 100 112.5 125 137.5 150
months 12 24 36 48 60 72 84 96 108 120 132 144
Engine
Engine accessory drive belt (I: icon , R: icon ) [Class 1] — I — I — R — I — I — R
[Class 2] — I — R — I — R — I — R
Camshaft timing belt (R: icon ) [Class 2] Replace every 140,000 km (87,500 miles) or 60 months.
Valve clearance (I: icon ) [Class 1] — I — I — I — I — I — I
Engine oil and engine oil filter (R: icon ) [Class 1] ACEA Standards or SUZUKI GENUINE OIL R R R R R R R R R R R R
[Class 1] Other than ACEA Standards or SUZUKI GENUINE OIL Replace every 15,000 km (9,375 miles) or 12 months.
[Class 2] Synthetic oil Replace when the oil change request light blinks or every 24 months.
Engine coolant (R: icon ) SUZUKI LLC: Super (Blue) *1 First time only: Replace at 160,000 km (100,000 miles) or 96 months.
Second time and after: Replace every 80,000 km (50,000 miles) or 48 months.
SUZUKI LLC: Standard (Green) Replace every 40,000 km (25,000 miles) or 36 months.
Exhaust system (except catalyst) (I: icon ) — I — I — I — I — I — I
Ignition
Spark plugs (R: icon ) When unleaded fuel is used [Class 1] (Highly recommended) Iridium plug *2 Replace every 100,000 km (62,500 miles) or 84 months.
[Class 1] (Standard type) Nickel plug *3 Replace every 40,000 km (25,000 miles) or 36 months.
When leaded fuel is used, refer to Maintenance Recommended under Severe Driving Conditions (Market Code P02, P22 and P54) schedule.
Fuel
Air cleaner filter element (R: icon , I: icon ) Paved road Inspect every 20,000 km (12,500 miles) or 12 months.
Replace every 40,000 km (25,000 miles) or 36 months.
Dusty condition Refer to Maintenance Recommended under Severe Driving Conditions (Market Code P02, P22 and P54) schedule.
Fuel lines (I: icon ) — I — I — I — I — I — I
Fuel filter (R: icon ) [Class 2] Replace every 60,000 km (37,500 miles).
Fuel tank (I: icon ) — I — I — I — I — I — I
Emission Control System
PCV valve (I: icon ) [Class 1] — — — I — — — I — — — I
Fuel evaporative emission control system (I: icon ) [Class 1] — — — — — I — — — — — I
Brake
Brake discs and pads (I: icon ) I I I I I I I I I I I I
Brake hoses and pipes (I: icon ) — I — I — I — I — I — I
Brake fluid (R: icon ) — R — R — R — R — R — R
Brake (Pedal and fluid level)
•Brake pedal (I: icon )
•Brake fluid level (I: icon )
 I I I I I I I I I I I I
Brake lever and cable (I: icon ) I: 1st 20,000 km (12,500 miles) only I — — — — — — — — — — —
Chassis and Body
Clutch fluid: (R: icon ) — R — R — R — R — R — R
Clutch (Pedal and fluid level)
•Clutch pedal: (I: icon )
•Clutch fluid level: (I: icon )
 I I I I I I I I I I I I
Tires / Wheels
•Tires: (I: icon )
•Wheels: (I: icon )
 I I I I I I I I I I I I
Drive axle boots / Propeller shafts (4WD)
•Drive axle boots: (I: icon )
•Propeller shafts (4WD): (I: icon )
 — I — I — I — I — I — I
Suspension system (I: icon ) — I — I — I — I — I — I
Steering system (I: icon ) — I — I — I — I — I — I
Manual transaxle oil (I: icon , R: icon ) Genuine “SUZUKI GEAR OIL 75W” Inspect every 40,000 km (25,000 miles) or 24 months.
Other than “SUZUKI GEAR OIL 75W” — R — R — R — R — R — R
Automatic transaxle (I: icon ) I I I I I I I I I I I I
Transfer oil (4WD) (I: icon , R: icon ) Inspect every 40,000 km (25,000 miles) or 24 months.
Replace every 160,000 km (100,000 miles) or 96 months.
Rear differential oil (4WD) (I: icon , R: icon ) Inspect every 40,000 km (25,000 miles) or 24 months.
Replace every 160,000 km (100,000 miles) or 96 months.
Twin clutch system actuation fluid (twin clutch system model) (I: icon ) Inspect every 105,000 km (65,625 miles) or 72 months.
All latches, hinges and locks (I: icon ) — I — I — I — I — I — I
Air conditioner filter element (if equipped) (I: icon , R: icon ) — I R — I R — I R — I R
NOTE:
•“R”: Replace or change
•“I”: Inspect, clean, adjust, lubricate or replace it if necessary
•*1: If SUZUKI super long life coolant (coolant color: Blue) is replaced with the other coolant, follow schedule for SUZUKI long life coolant (coolant color: Green).
•*2: If you replace the spark plugs other than iridium plug, follow the schedule of nickel plug.
•*3: For “Nickel plugs”, replace every 50,000 km (30,000 miles) if the local law requires.
•For specified spark plug, refer to Spark Plug Inspection:M16A.
K14C Engine Model
NOTE:
•For discrimination of market code, refer to Identification Plate.
•The intervals should be determined based on odometer readings or months, whichever comes first.
•The following table shows the service schedule up to 180,000 km (108,000 miles). Beyond 180,000 km (108,000 miles), perform the same maintenance services at the same intervals shown in the table.
•This table shows the typical maintenance schedule.
The actual maintenance schedule, however, varies depending on vehicle specifications, so the typical maintenance schedule may not be applicable to some models.
Therefore, for the maintenance schedule that is specifically applicable to the vehicle being serviced, follow the relevant instructions in the “Periodic Maintenance Schedule” under “INSPECTION AND MAINTENANCE” section of the Owner’s Manual.
Interval km (x 1,000) 15 30 45 60 75 90 105 120 135 150 165 180
miles (x 1,000) 9 18 27 36 45 54 63 72 81 90 99 108
months 12 24 36 48 60 72 84 96 108 120 132 144
Engine
Engine accessory drive belt (I: icon , R: icon ) — — I — — R — — I — — R
Engine oil and engine oil filter (R: icon ) R R R R R R R R R R R R
Engine coolant (R: icon ) SUZUKI LLC: Super (Blue) *3 First time only: Replace at 150,000 km (90,000 miles) or 96 months.
Second time and after: Replace every 75,000 km (45,000 miles) or 48 months.
SUZUKI LLC: Standard (Green) — — R — — R — — R — — R
Exhaust system (except catalyst) (I: icon ) — I — I — I — I — I — I
Ignition
Spark plugs (R: icon ) When unleaded fuel is used Iridium plug — — — R — — — R — — — R
When leaded fuel is used, refer to “K14C Engine Model” under Maintenance Recommended under Severe Driving Conditions (Market Code P02, P22 and P54) schedule.
Fuel
Air cleaner filter element (R: icon , I: icon ) Paved road I I R I I R I I R I I R
Dusty condition Refer to “K14C Engine Model” under Maintenance Recommended under Severe Driving Conditions (Market Code P02, P22 and P54) schedule.
Fuel lines (I: icon ) — I — I — I — I — I — I
Fuel tank (I: icon ) — — I — — I — — I — — I
Emission Control System
PCV valve (I: icon ) — — — — — I — — — — — I
Fuel evaporative emission control system (I: icon ) — — — — — I — — — — — I
Brake
Brake discs and pads (I: icon ) I I I I I I I I I I I I
Brake hoses and pipes (I: icon ) — I — I — I — I — I — I
Brake fluid (R: icon ) — R — R — R — R — R — R
Brake (Pedal and fluid level)
•Brake pedal (I: icon )
•Brake fluid level (I: icon )
 I I I I I I I I I I I I
Brake lever and cable (I: icon ) I: 1st 15,000 km (9,000 miles) only I — — — — — — — — — — —
Chassis and Body
Clutch fluid: (R: icon ) — R — R — R — R — R — R
Clutch (Pedal and fluid level)
•Clutch pedal: (I: icon )
•Clutch fluid level: (I: icon )
 I I I I I I I I I I I I
Tires / Wheels
•Tires: (I: icon )
•Wheels: (I: icon )
 I I I I I I I I I I I I
Drive axle boots / Propeller shafts (4WD)
•Drive axle boots: (I: icon )
•Propeller shafts (4WD): (I: icon )
 — — I — — I — — I — — I
Suspension system (I: icon ) — I — I — I — I — I — I
Steering system (I: icon ) — I — I — I — I — I — I
Manual transaxle oil (I: icon , R: icon ) Genuine “SUZUKI GEAR OIL 75W” Inspect every 30,000 km (18,000 miles) or 24 months.
Other than “SUZUKI GEAR OIL 75W” (I: 1st 15,000 km (9,000 miles) only) I — R — — R — — R — — R
Automatic transaxle (I: icon ) — I — I — I — I — I — I
Transfer oil (4WD) (I: icon , R: icon ) Inspect every 30,000 km (18,000 miles) or 24 months.
Replace every 150,000 km (90,000 miles) or 120 months.
Rear differential oil (4WD) (I: icon , R: icon ) Inspect every 30,000 km (18,000 miles) or 24 months.
Replace every 150,000 km (90,000 miles) or 120 months.
All latches, hinges and locks (I: icon ) — I — I — I — I — I — I
Air conditioner filter element (if equipped) (I: icon , R: icon ) — I R — I R — I R — I R
NOTE:
•“R”: Replace or change
•“I”: Inspect, clean, adjust, lubricate or replace it if necessary
•*3: If SUZUKI super long life coolant (coolant color: Blue) is replaced with the other coolant, follow schedule for SUZUKI long life coolant (coolant color: Green).
•For specified spark plug, refer to Spark Plug Inspection:K14C.