Suzuki Vitara (LY) 2016-2017 · Service Manual Scheduled Maintenance

Maintenance Schedule under Normal Driving Conditions (Except P02, P22, P54 and P71)

Precautions: General safety (00)

M16A Engine Model and D16AA Engine Model
NOTE:
•For discrimination of market code, refer to Identification Plate.
•The intervals should be determined based on odometer readings or months, whichever comes first.
•The following table shows the service schedule up to 180,000 km (108,000 miles). Beyond 180,000 km (108,000 miles), perform the same maintenance services at the same intervals shown in the table.
•This table shows the typical maintenance schedule.
The actual maintenance schedule, however, varies depending on vehicle specifications, so the typical maintenance schedule may not be applicable to some models.
Therefore, for the maintenance schedule that is specifically applicable to the vehicle being serviced, follow the relevant instructions in the “Periodic Maintenance Schedule” under “INSPECTION AND MAINTENANCE” section of the Owner’s Manual.
•Class 1: M16A engine
•Class 2: D16AA engine
Interval km (x 1,000) 15 30 45 60 75 90 105 120 135 150 165 180
miles (x 1,000) 9 18 27 36 45 54 63 72 81 90 99 108
months 12 24 36 48 60 72 84 96 108 120 132 144
Engine
Engine accessory drive belt (I: icon , R: icon ) [Class 1] — — I — — R — — I — — R
[Class 2] Inspect every 30,000 km (18,000 miles) or 24 months.
Replace every 120,000 km (72,000 miles) or 96 months.
Camshaft timing belt (R: icon ) [Class 2] Replace every 150,000 km (90,000 miles) or 60 months.
Valve clearance (I: icon ) [Class 1] — I — I — I — I — I — I
Engine oil and engine oil filter (R: icon ) [Class 1] except P37 R R R R R R R R R R R R
for P37 Replace every 10,000 km (6,000 miles) or 12 months.
[Class 2] Synthetic oil Replace when the oil change request light blinks or every 24 months.
Engine coolant (R: icon ) SUZUKI LLC: Super (Blue) *1 First time only: Replace at 150,000 km (90,000 miles) or 96 months.
Second time and after: Replace every 75,000 km (45,000 miles) or 48 months.
SUZUKI LLC: Standard (Green) — — R — — R — — R — — R
Exhaust system (except catalyst) (I: icon ) — I — I — I — I — I — I
Ignition
Spark plugs (R: icon ) When unleaded fuel is used [Class 1] (Standard type) Nickel plug — — R — — R — — R — — R
When leaded fuel is used, refer to Maintenance Recommended under Severe Driving Conditions (Except P02, P22, P54 and P71) schedule.
Fuel
Air cleaner filter element (R: icon , I: icon ) Paved road I I R I I R I I R I I R
Dusty condition Refer to Maintenance Recommended under Severe Driving Conditions (Except P02, P22, P54 and P71) schedule.
Fuel lines (I: icon ) — I — I — I — I — I — I
Fuel filter (R: icon ) [Class 1] except P37 and P90 Replace every 105,000 km (63,000 miles).
for P37 — — R — — R — — R — — R
[Class 2] Replace every 60,000 km (36,000 miles).
Fuel tank (I: icon ) — — I — — I — — I — — I
Emission Control System
PCV valve (I: icon ) [Class 1] — — — — — I — — — — — I
Fuel evaporative emission control system (I: icon ) [Class 1] — — — — — I — — — — — I
Brake
Brake discs and pads (I: icon ) I I I I I I I I I I I I
Brake hoses and pipes (I: icon ) — I — I — I — I — I — I
Brake fluid (R: icon ) — R — R — R — R — R — R
Brake (Pedal and fluid level)
•Brake pedal (I: icon )
•Brake fluid level (I: icon )
 I I I I I I I I I I I I
Brake lever and cable (I: icon ) I: 1st 15,000 km (9,000 miles) only I — — — — — — — — — — —
Chassis and Body
Clutch fluid: (R: icon ) — R — R — R — R — R — R
Clutch (Pedal and fluid level)
•Clutch pedal: (I: icon )
•Clutch fluid level: (I: icon )
 I I I I I I I I I I I I
Tires / Wheels
•Tires: (I: icon )
•Wheels: (I: icon )
 I I I I I I I I I I I I
Drive axle boots / Propeller shafts (4WD)
•Drive axle boots: (I: icon )
•Propeller shafts (4WD): (I: icon )
 — — I — — I — — I — — I
Suspension system (I: icon ) — I — I — I — I — I — I
Steering system (I: icon ) — I — I — I — I — I — I
Manual transaxle oil (I: icon , R: icon ) Genuine “SUZUKI GEAR OIL 75W” Inspect every 30,000 km (18,000 miles) or 24 months.
Other than “SUZUKI GEAR OIL 75W” (I: 1st 15,000 km (9,000 miles) only) I — R — — R — — R — — R
Automatic transaxle (I: icon ) — I — I — I — I — I — I
Transfer oil (4WD) (I: icon , R: icon ) Inspect every 30,000 km (18,000 miles) or 24 months.
Replace every 150,000 km (90,000 miles) or 120 months.
Rear differential oil (4WD) (I: icon , R: icon ) Inspect every 30,000 km (18,000 miles) or 24 months.
Replace every 150,000 km (90,000 miles) or 120 months.
Twin clutch system actuation fluid (twin clutch system model) (I: icon ) Inspect every 105,000 km (65,625 miles) or 72 months.
All latches, hinges and locks (I: icon ) — I — I — I — I — I — I
Air conditioner filter element (if equipped) (I: icon , R: icon ) — I R — I R — I R — I R
NOTE:
•“R”: Replace or change
•“I”: Inspect, clean, adjust, lubricate or replace it if necessary
•*1: If SUZUKI super long life coolant (coolant color: Blue) is replaced with the other coolant, follow schedule for SUZUKI long life coolant (coolant color: Green).
•For specified spark plug, refer to Spark Plug Inspection:M16A.
K14C Engine Model
NOTE:
•For discrimination of market code, refer to Identification Plate.
•The intervals should be determined based on odometer readings or months, whichever comes first.
•The following table shows the service schedule up to 120,000 km (72,000 miles). Beyond 120,000 km (72,000 miles), perform the same maintenance services at the same intervals shown in the table.
•This table shows the typical maintenance schedule.
The actual maintenance schedule, however, varies depending on vehicle specifications, so the typical maintenance schedule may not be applicable to some models.
Therefore, for the maintenance schedule that is specifically applicable to the vehicle being serviced, follow the relevant instructions in the “Periodic Maintenance Schedule” under “INSPECTION AND MAINTENANCE” section of the Owner’s Manual.
Interval km (x 1,000) 10 20 30 40 50 60 70 80 90 100 110 120
miles (x 1,000) 6 12 18 24 30 36 42 48 54 60 66 72
months 12 24 36 48 60 72 84 96 108 120 132 144
Engine
Engine accessory drive belt (I: icon , R: icon ) Inspect every 40,000 km (24,000 miles) or 48 months.
Replace every 80,000 km (48,000 miles) or 96 months.
Engine oil and engine oil filter (R: icon ) Except P37 R R R R R R R R R R R R
For P37 Replace every 7,500 km (4,500 miles) or 6 months.
Fuel injection (I: icon ) For P10, P37, P38 and P96 — — I — — I — — I — — I
Engine coolant (R: icon ) SUZUKI LLC: Super (Blue) *2 First time only: Replace at 150,000 km (90,000 miles) or 96 months.
Second time and after: Replace every 75,000 km (45,000 miles) or 48 months.
SUZUKI LLC: Standard (Green) Replace every 40,000 km (24,000 miles) or 36 months.
Exhaust system (except catalyst) (I: icon ) — — I — — I — — I — — I
Ignition
Spark plugs (R: icon ) When unleaded fuel is used Iridium plug — — — — — R — — — — — R
When leaded fuel is used, refer to “K14C Engine Model” under Maintenance Recommended under Severe Driving Conditions (Except P02, P22, P54 and P71) schedule.
Fuel
Air cleaner filter element (R: icon , I: icon ) Paved road I I I R I I I R I I I R
Dusty condition Refer to “K14C Engine Model” under Maintenance Recommended under Severe Driving Conditions (Except P02, P22, P54 and P71) schedule.
Fuel lines (I: icon ) — — I — — I — — I — — I
Fuel filter (R: icon ) except P37 and P90 Replace every 105,000 km (63,000 miles).
for P37 Replace every 45,000 km (27,000 miles) or 36 months.
Fuel tank (I: icon ) — — — I — — — I — — — I
Emission Control System
PCV valve (I: icon ) Inspect every 90,000 km (54,000 miles) or 108 months.
Fuel evaporative emission control system (I: icon ) Inspect every 90,000 km (54,000 miles) or 108 months.
Brake
Brake discs and pads (I: icon ) I I I I I I I I I I I I
Brake hoses and pipes (I: icon ) Inspect every 30,000 km (18,000 miles) or 24 months.
Brake fluid (R: icon ) Replace every 30,000 km (18,000 miles) or 24 months.
Brake (Pedal and fluid level)
•Brake pedal (I: icon )
•Brake fluid level (I: icon )
 I I I I I I I I I I I I
Brake lever and cable (I: icon ) I: 1st 10,000 km (6,000 miles) only I — — — — — — — — — — —
Chassis and Body
Clutch fluid: (R: icon ) Replace every 30,000 km (18,000 miles) or 24 months.
Clutch (Pedal and fluid level)
•Clutch pedal: (I: icon )
•Clutch fluid level: (I: icon )
 I I I I I I I I I I I I
Tires / Wheels
•Tires: (I: icon )
•Wheels: (I: icon )
 I I I I I I I I I I I I
Drive axle boots / Propeller shafts (4WD)
•Drive axle boots: (I: icon )
•Propeller shafts (4WD): (I: icon )
 Inspect every 40,000 km (24,000 miles) or 36 months.
Suspension system (I: icon ) Inspect every 30,000 km (18,000 miles) or 24 months.
Steering system (I: icon ) Inspect every 30,000 km (18,000 miles) or 24 months.
Manual transaxle oil (I: icon , R: icon ) Genuine “SUZUKI GEAR OIL 75W” Inspect every 30,000 km (18,000 miles) or 24 months.
Other than “SUZUKI GEAR OIL 75W” First time only: Inspect at 10,000 km (6,000 miles) or 12 months.
Replace every 40,000 km (24,000 miles) or 36 months.
Automatic transaxle (I: icon ) Inspect every 30,000 km (18,000 miles) or 24 months.
Transfer oil (4WD) (I: icon , R: icon ) Inspect every 30,000 km (18,000 miles) or 24 months.
Replace every 150,000 km (90,000 miles) or 120 months.
Rear differential oil (4WD) (I: icon , R: icon ) Inspect every 30,000 km (18,000 miles) or 24 months.
Replace every 150,000 km (90,000 miles) or 120 months.
All latches, hinges and locks (I: icon ) — — I — — I — — I — — I
Air conditioner filter element (if equipped) (I: icon , R: icon ) First set maintenance: Inspect at 30,000 km (18,000 miles) or 24 months.
Replace at 40,000 km (25,000 miles) or 36 months.
Second time and after: Repeat “First set maintenance” every 40,000 km (25,000 miles) or 36 months.
NOTE:
•“R”: Replace or change
•“I”: Inspect, clean, adjust, lubricate or replace it if necessary
•*2: If SUZUKI super long life coolant (coolant color: Blue) is replaced with the other coolant, follow schedule for SUZUKI long life coolant (coolant color: Green).
•For specified spark plug, refer to Spark Plug Inspection:K14C.