2007 Compass Patriot MK Factory Service Manual 5 - BRAKES

BRAKES - BASE

DESCRIPTION - BASE BRAKE SYSTEM

The base brake system consists of the following components:

The hydraulic brake system is diagonally split. That means the left front and right rear brakes are on one hydraulic circuit and the right front and left rear are on the other.

Disc brakes control the braking of both the front and rear wheels.

All vehicles are equipped with antilock brakes (ABS) and Electronic Stability Program (ESP). For more information on ABS and ESP, (Refer to 5 - BRAKES - DESCRIPTION).

The parking brake system consists of a hand-operated lever mounted between the front seats that actuates parking brake cables connecting to the rear brakes. For more information on Parking Brakes, (Refer to 5 - BRAKES/PARKING BRAKE - DESCRIPTION).

For information on the Stop Lamp Switch, (Refer to 8 - ELECTRICAL/LAMPS/LIGHTING - EXTERIOR/BRAKE LAMP SWITCH - DESCRIPTION).

WARNING

WARNING: Dust and dirt accumulating on brake parts during normal use may contain asbestos fibers from production or aftermarket brake linings. Breathing excessive concentrations of asbestos fibers can cause serious bodily harm. Exercise care when servicing brake parts. Do not sand or grind brake lining unless equipment used is designed to contain the dust residue. Do not clean brake parts with compressed air or by dry brushing. Cleaning should be done by dampening the brake components with a fine mist of water, then wiping the brake components clean with a dampened cloth. Dispose of cloth and all residue containing asbestos fibers in an impermeable container with the appropriate label. Follow practices prescribed by the Occupational Safety And Health Administration (OSHA) and the Environmental Protection Agency (EPA) for the handling, processing, and disposing of dust or debris that may contain asbestos fibers.

CAUTION

CAUTION: Use only Mopar® Brake Fluid DOT 3 Motor Vehicle or equivalent from a tightly sealed container. Do not use petroleum-based fluid because seal damage in the brake system will result. (Refer to 5 - BRAKES/HYDRAULIC/MECHANICAL/FLUID - SPECIFICATIONS)

CAUTION: Brake fluid will damage painted surfaces. If brake fluid is spilled on any painted surfaces, wash it off immediately with water.

CAUTION: Never use gasoline, kerosene, alcohol, motor oil, transmission fluid, or any fluid containing mineral oil to clean system components. These fluids damage rubber cups and seals.

CAUTION: During service procedures, grease or any other foreign material must be kept off the caliper assembly, brake linings, brake rotor and external surfaces of the hub.

CAUTION: When handling the brake rotor and caliper, be careful to avoid damaging the brake rotor and caliper, and scratching or nicking the brake shoe lining.