Repair Manual
INTRODUCTION
HOW TO USE THIS MANUAL
IDENTIFICATION INFORMATION
REPAIR INSTRUCTIONS
FOR ALL OF VEHICLES
HOW TO TROUBLESHOOT ECU CONTROLLED SYSTEMS
TERMS
PREPARATION
AUTOMATIC TRANSMISSION (A750F)
STEERING
SERVICE SPECIFICATIONS
STANDARD BOLT
AUTOMATIC TRANSMISSION (A750F)
SUSPENSION AND AXLE
STEERING
DIAGNOSTICS
AUTOMATIC TRANSMISSION (A750F for 1HD-FTE)
AUTOMATIC TRANSMISSION (A750F for 2UZ-FE)
ABS & HYDRAULIC BRAKE BOOSTER POWER SUPPLY SYSTEM
ABS & VEHICLE STABILITY CONTROL (VSC) & BRAKE ASSIST (BA) SYSTEM
VARIABLE GEAR RATIO STEERING
NAVIGATION SYSTEM
- HOW TO PROCEED WITH TROUBLESHOOTING ( 2003.8 - ) · PDF
- CUSTOMER PROBLEM ANALYSIS CHECK ( 2003.8 - ) · PDF
- PRE-CHECK ( 2003.8 - ) · PDF
- DIAGNOSTIC TROUBLE CODE CHART ( 2003.8 - ) · PDF
- PARTS LOCATION ( 2003.8 - ) · PDF
- TERMINALS OF ECU ( 2003.8 - ) · PDF
- PROBLEM SYMPTOMS TABLE ( 2003.8 - ) · PDF
- 1. Black screen (Nothing displayed) ( 2003.8 - ) · PDF
- 2. No sound with POWER switch pressed. (”Audio OFF” on audio screen) ( 2003.8 - ) · PDF
- 3. No navigation screen displayed when ”MAP”, ”Menu”, or ”DEST” switch pressed. (Screen cannot be switched.) ( 2003.8 - ) · PDF
- 4. No corresponding screen displayed when ”Audio” or ”Information” switch pressed. ( 2003.8 - ) · PDF
- 5. No navigation displayed, ”Audio OFF” on audio screen and no audio sound. ( 2003.8 - ) · PDF
- 6. Screen cannot be dimmed in night time. ( 2003.8 - ) · PDF
- 7. Navigation screen not stabilized (Synchronous error). ( 2003.8 - ) · PDF
- 8. Color on navigation screen is unusual (RGB signal error). ( 2003.8 - ) · PDF
- 9. Black screen appears when ”MAP”, ”Menu” or ”DESTINATION” switch pressed. ( 2003.8 - ) · PDF
- 10. Sound of radio, cassette tape or CD only cannot be heard from speaker. ( 2003.8 - ) · PDF
- 11. No sound (radio, cassette tape, DVD) can be heard from driver side door speaker only. ( 2003.8 - ) · PDF
- 12. Map DISC cannot be inserted. ( 2003.8 - ) · PDF
- 13. MAP screen display does not appear. (Disc Caution screen does not change) ( 2003.8 - ) · PDF
- 14. Map is displayed in white or blue screen. (Switches and vehicle position mark are displayed) ( 2003.8 - ) · PDF
- 15. Touch switch does not function. (Navigation screen only) ( 2003.8 - ) · PDF
- 16. Touch switch does not function. (A/C control screen only) ( 2003.8 - ) · PDF
- 17. Panel switch does not function. (Navigation screen only) ( 2003.8 - ) · PDF
- 18. Panel Switch Does Not Function (A/C control only) ( 2003.8 - ) · PDF
- 19. Navigation screen cannot change to the night mode color. ( 2003.8 - ) · PDF
- 20. Vehicle position is deviated from correct point badly. ( 2003.8 - ) · PDF
- 21. GPS mark does not appear. ( 2003.8 - ) · PDF
- 22. No voice navigation. ( 2003.8 - ) · PDF
- 23. Vehicle position rotates without control. (Map rotates without control) ( 2003.8 - ) · PDF
- 24. Driving direction is opposite to moving direction of vehicle position mark. ( 2003.8 - ) · PDF
- 25. Navigation system cannot be operated with voice recognition. ( 2003.8 - ) · PDF
- 26. Cellular Phone Registration Failure, Phone Directory Transfer Failure ( 2003.8 - ) · PDF
- 27. The Cellular Phone cannot Send/Receive ( 2003.8 - ) · PDF
- 28. Cannot Call in a Certain Place ( 2003.8 - ) · PDF
- 29. Voice on Phone Cannot be Heard, too Quiet, or Distorted ( 2003.8 - ) · PDF
- 30. Own Voice Cannot be Heard, Quiet or Distorted ( 2003.8 - ) · PDF
- AVC-LAN (Communication bus) Circuit ( 2003.8 - ) · PDF
- Power Source Circuit (Navigation ECU) ( 2003.8 - ) · PDF
- Power Source Circuit (Multi-Display Assembly) ( 2003.8 - ) · PDF
- Power Source Circuit (Network Gateway ECU) ( 2003.8 - ) · PDF
- Speaker Circuit ( 2003.8 - ) · PDF
- Display Signal Circuit ( 2003.8 - ) · PDF
- Reverse Signal Circuit ( 2003.8 - ) · PDF
REAR VIEW MONITOR SYSTEM ( 2003.8 - )
AUTOMATIC TRANSMISSION (A750F)
VALVE BODY ASSEMBLY
AUTOMATIC TRANSMISSION UNIT (2UZ-FE)
AUTOMATIC TRANSMISSION UNIT (1HD-FTE)
SUSPENSION AND AXLE
TROUBLESHOOTING
FRONT WHEEL ALIGNMENT
STEERING
STEERING WHEEL
POWER TILT AND POWER TELESCOPIC STEERING COLUMN
POWER STEERING GEAR (Independent Front Suspension)